Browsing by Author "Brei, Volodymyr"
Now showing 1 - 3 of 3
Results Per Page
Sort Options
Item Study of a continuous process of glycerolysis of rapeseed oil with the solid base catalysts(Publishing House of Lviv Polytechnic National University, 2012) Brei, Volodymyr; Starukh, Galyna; Levytska, Svitlana; Shistka, DmytroGlycerolysis of rapeseed oil over several solid bases using fixed bed flow reactor has been studied. It was found that Mg-Al hydrotalcite and Al2O3 supported CaO–ZnO demonstrate high activity in this reaction. The yield of monoglycerides reaches 70 % with 96 % oil conversion at 513 K. It was shown that pores size of a catalyst is an important factor of intensification of the glycerolysis process. It was found that turpentine additive decreases the reaction temperature due to higher solubility of glycerol in oil. Досліджено процес гліцеролізу ріпакової олії на твердих основних каталізаторах в проточному реакторі зі стаціонарним шаром каталізатора. Знайдено, що Mg-Al-гідроталькіт і CaO-ZnO/Al2O3 проявляють високу активність в цій реакції. Вихід моногліцеридів досягає 70 % при 96 % конверсії олії за 513 K. Показано, що розмір пор каталізатора є важливим фактором в процесі гліцеролізу. Знайдено, що додавання скипидару дозволяє знизити температуру реакції завдяки збільшенню розчинності гліцерину в олії.Item Superacid ZrO2-SiO2-SnO2 Mixed Oxide: Synthesis and Study(Видавництво Львівської політехніки, 2021-03-16) Prudius, Svitlana; Hes, Natalia; Trachevskiy, Volodymyr; Khyzhun, Oleg; Brei, Volodymyr; Institute of Sorption and Problems of Endoecology of the NAS of Ukraine; Technical Center of the NAS of Ukraine; Frantsevich Institute for Problems of Materials Science of the NAS of UkraineСуперкислотні потрійні ZrO2 SiO2 SnO2 оксиди (Н0 = –14.52) синтезовано золь-гель методом з атомним співвідношенням в межах: 20 ≤ Zr4+ ≤ 29, 60 ≤ Si4+ ≤ 67, 11 ≤ Sn4+ ≤ 20 %. Суперкислотність ZrO2 SiO2 SnO2 оксиду пояснена формуванням координаційно-ненасичених Zr4+ йонів, як сильних центрів ЛьюїсаItem Two-stage conversion of glycerol into propylene glycol over Cu/Al2O3 catalyst(Publishing House of Lviv Polytechnic National University, 2015) Sharanda, Mykhailo; Sontsev, Vladyslav; Bondarenko, Evgeniya; Brei, VolodymyrThe conversion of 30 % glycerol mixture in ethanol over Cu/Al2O3 catalyst at 493 K/0.1MPa was studied under Ar-H2 flow with different H2 content. It was shown, that 84 % selectivity towards hydroxyacetone is achieved at using 2.5 % H2 concentration in a carrier gas. Then the product obtained at 493 K has been hydrogenated into a propylene glycol at 448 K in pure H2 flow under 1.2 MPa. 89 % selectivity towards propylene glycol was achieved at moderate consumption of hydrogen H2/C3H6O2 = 4 (mol). Two-stage conversion of glycerol into the propylene glycol at different pressure is proposed. Досліджено перетворення 30% розчину гліцерину в етанолі на Cu/Al2O3 каталізаторі при 493 K/0,1 МПа в потоці Ar-H2 з різним вмістом Н2. Показано, що 84% селективність за гідроксиацетоном досягається при концентрації H2 в газі-носії 2,5%. Проведено гідрування отриманого продукту в пропіленгліколі при температурі 448 К в потоці чистого H2 при 1,2 МПа. При середній витраті водню H2/C3H6O2 = 4 моль досягнуто 89% селективності відносно пропіленгліколю. Показана можливість двостадійного перетворення гліцерину в пропіленгліколь за різних тисків.